The EPA Placed a Texas Superfund Site on its National Priorities List in 2018. Why Is the Health Threat Still Unknown?

Predominantly Latino residents in Grand Prairie, west of Dallas, say they’ve been told little or nothing about air, soil and groundwater poisoned by TCE, a known human carcinogen.

A local elementary school is just down the street from the superfund site and Grand Prairie’s water tower. Credit: Keren Carrion

A local elementary school is just down the street from the superfund site and Grand Prairie’s water tower. Credit: Keren Carrion

Share this article

First in a series with KERA in Dallas on the Delfasco Forge Superfund site in Grand Prairie, Texas, produced with the support of  Investigative Editing Corps in a pilot project with Report for America.

The Beltrán family always stocks two to three cases of bottled water in the cluttered garage of their home in Grand Prairie, Texas. They’ve used it to drink and cook for 15 years. And they trek to the nearest Walmart to stay fully stocked. 

“We got here and the water was salty, super salty,” Santa Barbara Beltrán, 72, said in Spanish. “We buy jugs of water for cooking.”

Her family has lived in Grand Prairie, west of Dallas, for over 30 years, and she said it’s a common belief among her neighbors that Grand Prairie’s water is not safe to drink because “contamination floods the streets of the neighborhood.”

Newsletters

We deliver climate news to your inbox like nobody else. Every day or once a week, our original stories and digest of the web’s top headlines deliver the full story, for free.

Interviewed inside her kitchen, Beltrán said she knew nothing about the Superfund toxic waste site two blocks away. But it’s possible the talk she’d heard for years about contaminated water wasn’t about Grand Prairie’s supply of surface water for drinking, but referred to a plume of highly polluted groundwater that’s spread beneath the neighborhood. 

The Environmental Protection Agency added the Superfund site, once occupied by a company called Delfasco Forge, to the National Priorities List in 2018, its registry of “the nation’s most serious uncontrolled or abandoned hazardous waste sites.” 

Tests showed that trichloroethylene (TCE), a highly toxic chemical used to clean machinery, had contaminated soil at the site, seeped into the groundwater and vaporized into the air from the groundwater plume. That affected about 80 homes in the neighborhood.

Despite Delfasco’s inclusion on the NPL more than three years ago, EPA documents show that the agency still lacks data on whether the human health threat is under control, or if the groundwater contamination has been contained.

KERA knocked on more than two dozen doors in the predominantly Latino neighborhood of Burbank Gardens and conducted extensive interviews with residents. Most knew nothing about the Superfund site or the ongoing health threat. 

Delfasco Forge, a defense contractor, manufactured military suspension lugs used to attach weapons to aircraft bomb racks from 1980 to 1998. The company declared bankruptcy in 2008, in part because of liabilities related to the cleanup. 

Operators at Delfasco Forge used TCE to clean machinery and then simply drained it into the soil on the 1.25-acre site. In a study commissioned by the EPA, EA Engineering, Science, and Technology, Inc., found that “a review of building drawings indicate open pits may have been present in the shop building…and that these pits were connected to floor drains….”

Inhalation of trichloroethylene can lead to respiratory diseases, neurological effects like dizziness, headaches, confusion, depression and cancer. A 2009 study by the Texas Department of State Health Services and the Texas Environmental Health Institute found a high correlation between indoor air concentrations of TCE and TCE in the blood of residents living in those homes, according to the EA Engineering report. 

Beltrán’s home is tucked away in Burbank Gardens, a residential, low-income, predominantly Latino neighborhood. Like many communities of color, it’s near a landfill, multiple industrial facilities—and the Superfund site.  

Santa Barbara Beltrán, 72, has spent over 15 years buying bottled water and cooking with potable water. Credit: Keren Carrion
Santa Barbara Beltrán, 72, has spent over 15 years buying bottled water and cooking with potable water. Credit: Keren Carrion

Her family could hear a hammering noise that would come from Delfasco Forge during the day after they first moved in. The noise came from a hammer forge that made the suspension lugs.

Beltrán said she heard about the site’s contamination once 10 years ago, but her knowledge is very limited. Like many undocumented immigrants who fear deportation, she is wary about talking with government officials. She said she’s never talked directly to anyone from the EPA, even though she’s concerned about her health and safety. 

“Can you imagine the continuous contamination on the soil by chemicals from factories?” Beltran asked. “But since I don’t know English, I understand little.”

Feeling powerless, Beltrán now wonders if the site’s contamination may be linked to a couple of cancer cases on her block. She wonders, too, whether it may be related to her son’s illness. Roy, 44, has been diagnosed with lupus.

“I know that there have been many people with cancer on this street,” she said. 

How a Grand Prairie Site Landed on the NPL 

Cindy Mendez, Grand Prairie’s director of public Health and Environmental Quality, said

environmental protections were limited after the site closed in the late 1990s. 

“People really didn’t know what the hazards were with a lot of these chemicals that they were using,” she said. 

The Texas Commission on Environmental Quality first detected soil and groundwater contamination at the site in 2002. The agency detected TCE and numerous other volatile organic compounds. Responding to the contamination became a top priority for the TCEQ because many residents living in older homes relied on groundwater wells for their drinking water.

Mendez said state environmental agencies tried to remove the chemicals from the soil and groundwater. But technology at the time was not effective. 

In 2008, the EPA stepped in and conducted further studies that found extensive contamination by TCE in the soil at the site and in the groundwater migrating beneath the neighborhood. Vapor containing TCE from the soil and groundwater also was detected inside residents’ homes. 

Chris Villarreal, the EPA’s Texas section chief for the Superfund and Emergency Management Division, said exposure to contaminants from the site now comes from “what we refer to as vapor intrusion.” Delfasco Forge was, in fact, one of the first two sites in the country added to the National Priorities List for vapor intrusion. 

Villareal said TCE levels in the neighborhood exceeded the EPA’s regional screening thresholds for potential cancer impact. 

The EPA concluded that 81 homes needed vapor systems to clean the air. But only 34 homes received those systems in 2014. Funds from the bankruptcy settlement paid for them.

Keep Environmental Journalism Alive

ICN provides award-winning climate coverage free of charge and advertising. We rely on donations from readers like you to keep going.

Donate Now

You will be redirected to ICN’s donation partner.

Tests of those systems, also in 2014, produced “mixed results” with some samples showing “lower and some showing higher concentrations” of TCE in the air, the EA Engineering report said. 

“There’s been several outreach attempts. We’ve had several public meetings in the neighborhood,” Mendez said. “All of our education is … bilingual and our meetings are done in a bilingual setting.” 

George Craig, 58, lives in a wooden frame house five minutes from the site. He said there is always a “funny smell” in and around his home. 

“It’s almost like somebody puts on too much perfume, and it’s really strong when you first smell it,” Craig said. 

Craig is one of many neighborhood residents who had a groundwater well on their properties. The city informed him not to use the well water because of the TCE contamination. 

“I’ve been here 20 years and I’ve never been able to use it,” he said. 

Craig said he didn’t understand the extent of the contamination or what it meant, but he was among the residents who agreed to have vapor systems installed in their homes. 

Craig said lightning struck and “blew up” the vapor fan about five years ago. Craig said he tried calling the city, but couldn’t get through. Since then, the system hasn’t been fixed, and no one has checked in to see if it is working. 

The James Fannin Middle School is less than a block from the Delfasco Forge site. On any given weekday around 3 p.m., students can be seen outside the school on the football and soccer field framed by the Superfund site. 

Schools officials attended the last community meeting held for homeowners by EPA and Grand Prairie officials in 2018. 

“One of the things that they did tell us during that meeting and have told us since is that our school is in no danger from that contamination site,” said Sam Buchmeyer, public information officer for Grand Prairie Independent School District. 

The water contamination from the site is associated with a groundwater plume that’s moving the contaminated water northeast from the site, away from the school, EPA officials said.

Robert Molina, 56, said his father, Henry, also refuses to drink faucet water. Molina hadn’t heard anything about the Superfund site, even though he’s lived in Grand Prairie his entire life. But he said he assumed something wasn’t right when he saw the city boarding up one of its oldest wells located near a park and recreation center not far from his home in the neighborhood. 

“They kind of forgot about this area,” he said of city officials.  “A lot of us are from low-income families and so we never heard.” 

Molina said the possible health risks posed by the Superfund site are among the many examples of communities of color facing disproportionate burdens from pollution. He wants more answers from the city about the potential health impacts.  

A Host of Environmental Justice Issues

Molina and others in the neighborhood said that the long, drawn out and, so far, incomplete cleanup efforts raise a host of environmental justice issues. Molina said he wants transparent communication—and for the site to be cleaned up faster. 

The EPA’s Villareal said the Covid-19 pandemic has been partially to blame. 

“We’ve been unable to do our traditional outreach that we generally do for Superfund sites,” he said. “But as we go forward and, as you know, as things evolve, hopefully we’ll be able to get back into the community and do our door-to-door and public meetings.”

A 90-year-old covid-survivor in Grand Prairie drinks only bottled water to keep him safe from the city's contaminated water. Credit: Keren Carrion
A 90-year-old covid-survivor in Grand Prairie drinks only bottled water to keep him safe from the city’s contaminated water. Credit: Keren Carrion

The Biden administration recently passed a $1.2 trillion infrastructure bill that includes $3.5 billion for Superfund site cleanup nationally. How the money will be allocated among over 1,300 sites on the National Priorities List is not yet clear.

“EPA is working to ensure at least 40 percent of Superfund work will be conducted to address environmental justice concerns,” Jennah Durant, the spokesperson for EPA Region 6 in Dallas, said in an email. “No community deserves to have contamination near where they live, work, pray and go to school.” 

Alejandra Martinez is a Report For America corps member for KERA News. Email Alejandra at amartinez@kera.org. You can follow Alejandra on Twitter @alereports.